Powermatic 2 Plus: The Ultimate Guide for Smokers

The Powermatic 2 Plus is an electric cigarette injector machine designed for smokers who want a consistent, tightly packed cigarette without the frustration of manual rolling. It works with loose tobacco and empty tubes to produce machine-quality cigarettes at home. If you roll regularly, this machine saves time and money every single session.

What Is the Powermatic 2 Plus and How Does It Work?

The Powermatic 2 Plus is a tabletop electric injector that feeds loose tobacco into standard cigarette tubes with the press of a lever. You load the tobacco tray, place an empty tube on the spout, press down, and the machine does the packing in under three seconds. No uneven burns, no loose ends, no wasted tobacco.

• Fill the tobacco chamber with your preferred loose-cut tobacco
• Slide a standard 100mm or king-size tube onto the injector spout
• Press the lever down firmly until it locks
• Release and pull the finished cigarette free
• Repeat — the whole process takes about four seconds per cigarette

The machine uses a motorized auger system that compresses tobacco evenly before injecting it into the tube. This is what separates it from cheaper spring-loaded injectors, which often produce a cigarette that is too loose at one end and too tight at the other.

Powermatic 2 Plus vs Manual Rolling: Which One Actually Saves You More?

If you smoke half a pack a day, switching from store-bought cigarettes to a machine like the Powermatic 2 Plus can save you over $1,000 per year in most U.S. states. Manual rolling gets you part of the way there, but the Powermatic eliminates the learning curve and the wasted tobacco from poorly rolled tubes.

• Speed: Manual rolling takes 30 to 60 seconds per cigarette. The Powermatic 2 Plus takes under 5 seconds.
• Consistency: Hand-rolled cigarettes vary in density. The Powermatic packs the same amount of tobacco every time.
• Tube compatibility: The Powermatic works with both 100mm and king-size tubes. Most manual rollers are locked to one size.
• Tobacco waste: Manual rollers spill and over-pack. The Powermatic chamber holds exactly what you load.
• Effort: Manual rolling causes finger fatigue over time. The Powermatic is one press of a lever.

According to a cost analysis published by TobaccoReviews.com, rolling your own cigarettes can reduce per-cigarette cost to as low as 10 to 15 cents, compared to 35 to 50 cents per cigarette in a commercially purchased pack in many states. The Powermatic pays for itself within the first few weeks of regular use.

How to Get the Best Results from the Powermatic 2 Plus

The biggest mistake new users make is overpacking the tobacco chamber. The Powermatic 2 Plus works best when you fill the tray to the line and use a tobacco with medium moisture content. Too dry and the cigarette burns fast and loose. Too moist and the machine jams.

1. Check your tobacco moisture: Squeeze a pinch between your fingers. It should hold its shape briefly, then fall apart. That is the right consistency.
2. Fill to the indicator line: Do not heap tobacco above the tray rim. A level fill produces a firm, even cigarette.
3. Use quality tubes: Cheap tubes collapse on the spout and cause jams. Standard filter tubes from recognized brands fit the Powermatic spout cleanly.
4. Clean the auger weekly: Tobacco residue builds up in the auger channel and causes uneven packing. A pipe cleaner and a small brush clear it in two minutes.
5. Store tobacco in a sealed container: Once tobacco dries out, no machine packs it well. An airtight jar or humidor pouch keeps it at the right moisture level between sessions.

What Tobacco Works Best in the Powermatic 2 Plus?

The Powermatic 2 Plus is designed for fine-cut and medium-cut loose tobacco, not pipe tobacco or whole-leaf tobacco. Pipe tobacco is cut too coarse and too moist, which will jam the auger. Fine-cut cigarette tobacco flows through the chamber cleanly and packs without resistance.

• Fine-cut cigarette tobacco: Ideal. Flows through the auger with no clumping.
• Medium-cut cigarette tobacco: Works well with slightly lighter fills.
• Pipe tobacco (rehydrated and broken down): Can work in small quantities, but expect slower operation and more frequent cleaning.
• Whole-leaf or plug tobacco: Do not use. Will jam the machine and may damage the auger motor.

According to the manufacturer's documentation for the Powermatic 2 Plus, the machine is rated for standard rolling tobacco cuts and is not designed for pipe or specialty blends without modification. Using the correct cut extends the life of the auger significantly.

How to Clean and Maintain the Powermatic 2 Plus

A clean Powermatic 2 Plus lasts for years. A neglected one jams within months. Tobacco resin and dried leaf fragments build up inside the auger housing after every session. A five-minute weekly cleaning routine prevents 90 percent of the mechanical problems users report online.

1. Unplug the machine before cleaning — always.
2. Remove the tobacco tray and shake out any loose tobacco.
3. Use a small stiff brush to sweep the auger channel from the tray end toward the spout.
4. Run a dry pipe cleaner through the spout to clear any compressed tobacco near the tube opening.
5. Wipe down the exterior with a dry cloth — do not use water near the motor housing.
6. Reassemble and test with a single tube before your next full session.

What Accessories Pair Well with the Powermatic 2 Plus

The Powermatic 2 Plus handles injection, but the rest of your smoking setup matters too. The right storage, rolling backup, and organization tools make the whole experience cleaner and more convenient. At FESSONLINE, several products pair directly with the kind of smoking routine the Powermatic supports.

• 100mm Cigarette Case 3-Pack (FESSONLINE): Once your cigarettes are rolled, you need somewhere to put them. This flip-top case holds 18 cigarettes and fits the 100mm length that matches one of the Powermatic's standard tube settings. It keeps your rolled cigarettes from getting crushed in a bag or pocket.
• 110mm Hand Cigarette Roller (FESSONLINE): A manual backup for travel or when you do not want to set up the full machine. The 110mm roller produces a consistent tube when you are away from your desk.
• 12-Pipe Tobacco Stand 2-Level Wood Holder (FESSONLINE): If you also smoke a pipe alongside your rolled cigarettes, this stand keeps your pipes organized and off the table surface, which reduces stem damage over time.

Is the Powermatic 2 Plus Worth the Price?

The Powermatic 2 Plus costs more than a basic manual injector, and that cost difference is worth it if you roll more than five cigarettes a day. At that volume, the speed advantage alone adds up to real time saved each week, and the consistent pack quality means you waste less tobacco per session.

If you only roll occasionally or travel frequently, a compact manual roller like the 110mm Hand Cigarette Roller from FESSONLINE may serve you better as a primary tool. But for a daily smoker with a fixed rolling station, the Powermatic 2 Plus is the most efficient option in its category.

The break-even point for most daily smokers is between three and six weeks, depending on tobacco cost in their region and how many cigarettes they roll per day.

Frequently Asked Questions

Can the Powermatic 2 Plus use 100mm tubes?

Yes. The Powermatic 2 Plus is compatible with both 100mm and king-size cigarette tubes. You adjust the machine's tube stop to match the length you are using. The FESSONLINE 100mm Cigarette Case holds up to 18 of the finished cigarettes, which makes it a practical storage companion for a full session of 100mm rolling.

Why does my Powermatic 2 Plus keep jamming?

Jams are almost always caused by tobacco that is too moist, cut too coarse, or overpacked into the chamber. Check that you are using fine-cut or medium-cut cigarette tobacco, that the moisture level is correct (holds shape briefly, then crumbles), and that you are not filling above the chamber line. Clean the auger channel with a stiff brush after each use to prevent residue buildup from compounding the problem.

How long does the Powermatic 2 Plus last?

With regular cleaning and correct tobacco use, most Powermatic 2 Plus machines last between three and seven years of daily use. The auger motor is the component most likely to wear out first, and it typically shows signs of slowing before it fails completely, which gives you time to plan a replacement. Avoid running the machine dry or forcing the lever, as both put unnecessary strain on the motor.

What is the difference between the Powermatic 2 and the Powermatic 2 Plus?

The Powermatic 2 Plus features a more powerful motor and an improved auger design compared to the original Powermatic 2. In practical terms, the Plus handles slightly denser tobacco cuts with less resistance and produces a more consistent pack across different tobacco blends. For most users, the Plus is worth the small price difference because it reduces jamming frequency and extends the service life of the machine.